(De)Evolution of the BMW 3 series ventilation and heating systems

John Avis by | January 28, 2016 | E36 E30

I have a strong disliking of the climate control system in my BMW E36, but in my previous E30, the controls for ventilation, heating and air conditioning were near perfect.
BMW E30 - E36 controls

I have a strong disliking of the climate control system in my BMW E36, but in my previous E30, the controls for ventilation, heating and air conditioning were near perfect.

Let's look at the E30 system. There are controls for fan speed, temperature, air conditioning, recirculating mode, and individual controls to vary the flow to the windscreen, face level, and feet.

With the fan off, you could still have natural airflow if any of the position controls were open, and recirculating mode was not on.

You could vary the flow of air to any level, however you liked.

Now let's look at the digital climate control system fitted to late model E36s.

It has dual temperature controls. Sure it's nice to have the system automatically maintain the temperature but I've never been a fan of dual systems. Most of the time I find myself setting both temperature settings the same, so it's just two controls to adjust each time. Also, in every E36 I've owned the solenoids that manage the coolant flow for this function have failed.

Then there's a fan speed control. Again, it's nice there's an automatic mode that adjusts the fan speed to maintain the temperature. But there is no way of having natural airflow. It's either fan and airflow on or off altogether.

There's buttons to enable airflow to the windscreen, face level, or feet level, including an automatic mode (which I'm not sure what it does - presumably make all levels of the car the same temperature. You can't have a little flow to one area, and a lot to another like you could on the E30.

The E36 system does have a handy demist setting for the front windscreen. But what about the rear window? On the E30 you could switch on the rear window demister independently of the ventilation system. On the E36 you cannot have the rear window demister on without the ventilation fan on. Why?

One of the worst parts of the E36 system is the separate control for heat to the face level vents. I recall when the E30 was introduced, some journalists criticised it because you couldn't have different temperature settings for face and feet. So on the E36 we now have a separate control for the face level vents to set it for hot and cold.

Even though I've owned several E36s over quite a few years I am still unsure how to control this. Does it still blow hot air to the face if I have the climate control set to a low temperature but the face level vent set to heat? If I have the face level set to cold but the climate control set to hot what temperature do I get? It seems such a pointless system.

The E30 system was reliable except for the fan motor resistor pack which failed due to loose rivets or a dirty switch contact. The E36 system has the common problem with the coolant solenoids that I mentioned, plus the electronic control module itself is prone to problems with capacitors.

Sometimes the simpler the system is, the better it is. I miss my E30.

Related Posts

E36

Japanese BMW M44 engine document

by John Avis | September 9, 2019

I found this Japanese document, presumably from BMW, that covers the M44 engine.


E36

Top 3 performance modifications for a street driven BMW E36

by John Avis | January 23, 2015

If you are looking for the best modifications you can do to your BMW 3 series from 1991 to 1997, here's my top 3 list for the modifications that you will notice the most improvement.


E36

1994/1995 BMW E36 318is Sport Option Pack

by John Avis | March 25, 2013

In October 1994 BMW Australia introduced a sport option pack for the 318is coupe. This option pack included 16-inch alloys and certain M-Technic parts. I've seen three such 318is's around. Apparently the sports option pack was also offered on the 325i but I haven't seen any of those.

Comments

JOL71

by JOL71 | August 28, 2016

I agree with you about some of the quirks with the E36 heating controls.
My biggest gripe is that whenever the car is started the fan will automatically go on, even if the driver specifically turned it off before shutting off the previous time car was driven

Reply

Leave a Reply

Tags

Subscribe

Get the latest posts delivered to your inbox.